OPTIMALISASI DESAIN KENDALI KECEPATAN PUTAR MOTOR INDUKSI TIGA FASA BERBASIS FPGA

Tole Sutikno

Abstract


FPGA based the problem of implementation of PWM signal generating system is solution of transformation to digital gate logic space. These stages are done with sampling, quantizing and coding. Best resolution of sampling and carrier frequency, so result of PWM generating is better, but it required most digital gate. Aim of this research is optimization of last research adjustable speed drive of three-phase induction motor; with improve resolution of sampling and carrier frequency, and minimalization of digital gate used with Quine Mc Cluskey method. Result of this research indicate that the design of optimalized SPWM generating signal can be realized in hardwared-logic in ACEXIK FPGA to drive inverter as speed controller turn around the three phase induction motor, with requiring 1629 logic cell. Adjustable motor speed designed can be done by through setting make a modulation index and frequency. At this research, system have been tested at setting frequency 3-50 Hz with the variation of modulation index, and can adjustable three phase induction motor speed in  range  117-1468 rpm.

Full Text:

PDF

References


. Baker, M.S., Application Criteria For The Selection of Electronic Variable Speed Drive, Proceeding Conference on Industrial Drive, Universitas of Central Queensland, Rockhampton, 1991.

. Gunawan, R. dan Dwijatmiko, T., Kendali Kecepatan Putar Motor Induksi Tiga Fasa Berbasis Logika Fuzzy dan Mikrokontroler AT89C52, Industrial Electronics Seminar (IES 2004), PENS-ITS, Surabaya, 2004.

. Irwin, J.D., Industrial Electronics Handbook, CRC Press and IEEE Press, Boca Raton, Florida, 1997.

. Sutikno, T., dkk., Perancangan Sistem Kendali Kecepatan Putar Motor Induksi Dengan Teknik UPWM, SPWM dan MSPWM Berbasis FPGA ACEX1K, Laporan PHB Ditjen Dikti Depdiknas, Yogyakarta, 2006.

. Sutopo, B., Wijaya, F.D., dan Supari, Perbaikan Faktor Daya Motor Induksi 3 Fasa Menggunakan Mikrokontroler 68HC11, Industrial Electronics Seminar (IES 2001), PENS-ITS, Surabaya, 2001.

. Bashi. S.M., Aris, I. and Hamad, S.H., Development of Single Phase Induction Motor Adjustable Speed Control Using M68HC11E-9 Microcontroller, Asian Network for Scientific Information, Journal of Applied Sciences 5 (2): 249-252, ISSN 1812-5654, 2005.

. Grant, D.A., and Seidner, R., Ratio Changing in Pulse-width-Modulated Inverters, IEER Proc. B., Vol.128, No.5, 1981.

. Hendriawan, A., dkk., Implementasi FPGA Sebagai Pembangkit Pulsa Pada Inverter 3 Fasa 18-Step dengan Topologi Triple Choper Triple Bridge Inverter, Industrial Electronics Seminar (IES 2004), PENS-ITS, Surabaya, 2004.

. Hildebrand, E.N., and Roehrdanz, H., Losses in Three Phase Induction Machines Fed by PWM Converter, IEEE Tranc. On energy Convertion, Vol.16, No.3, 2001.

. Irwin, J.D., Industrial Electronics Handbook, CRC Press and IEEE Press, Boca Raton, Florida, 1997.

. Lazic, M., and Skender, M., Generating Driving signal for Three Phases Inverter by Digital Timing Functions, Facta Universitatis (NIS) Series: Electronics and Energetics, Vol. 13, No. 3, Hal: 353-364, Des 2000.

. Mohan, N., Undeland, T.M., and Robbins, W.P.. Power Electronics, Converters, Applications, and Design, Second Edition, John Wiley & Sons, Singapore, 1995.

. Rashid, M.H., Power Electronics Circuits, Devices, and Applications, Second Edition, Prentice-Hall International, Inc., London, 1993.

. Sutikno, T., dkk, Proses Pembangkitan MSPWM Tiga Fasa Berbasis FPGA ACEX1K, Seminar Nasional Technosim II, Jurusan Teknik Mesin dan Industri (JTMI), FT-UGM, Yogyakarta., 2006.

. Tamrakar, I., and Malik, O.P., Power Factor Corection of Induction Motor Using PWM Inverter Fed Auxiliary Stator Winding, IEEE Transc. on Energy Convertion, Vol.14, No.3, 1999.

. Lazic, M., and Skender, M., Generating Driving signal for Three Phases Inverter by Digital Timing Functions, Facta Universitatis (NIS) Series: Electronics and Energetics, Vol. 13, No. 3, Hal: 353-364, Des 2000.

. Baronti, F., etc., DC/DC Switching Power Converter with Radiation Hardened Digital Control based on SRAM FPGAs, Disertation, Department of Information Engineering, University of Pisa, Pisa, 2003.

. Guilberto, J., et.al., An Autonomous Robot with Reconfigurable Hardware and RT Linux For Fire-Fighting, Intelligent Systems and Robotics Group, Electrical Engineering Department, New Mexico Institute of Mining and Technology, New Meksiko, 2002.

. Li , H. and Jiang, Q., Design of a FPGA Controller for Full Bridge Phase-Shifted Zero Voltage Switching DC/DC Power Converters, Disertation, School of Communications and Informatics, Victoria University, Melbourne City, 1999.

. Noorfatchurrudin, Kendali Kecepatan Motor Induksi Satu Fasa Dengan Inverter PWM Sinusoida berbasis FPGA Altera ACEX1K, Tugas Akhir, Teknik Elektro Universitas Ahmad Dahlan, Yogyakarta, 2005.

. Ritter, G., Puiatti, J.M., and Sanchez, E., Leonardo and Discipulus Simplex: An Autonomous, Evolvable Six-Legged Walking Robot, Logic System Laboratory, Swiss Federal Institute of Technology, Lausanne, 2003.

. Takahashi, T., New Digital Hardware Control Method for High Performance AC Servo Motor Drive–AcceleratorTM Servo Drive Development Platform for Military Application, As presented at Military Electronics Conference, Sept 24-25, International Rectifier (IR) , 2002.

. Dewan, S.B., Slemon, G.R., and Straughen, A., Power Semiconductor Circuits, John Wiley and Sons, Inc., Toronto, 1984.

. Leao, A.T., et.al., A Robust Fuzzy Speed control Applied to a Three-Phase Inverter Feeding a Three-Phase Induction Motor, IEEE Transc. on Power Electronics, Vol.17, No.3, 2002.

. Marco, A., Sanvido, A., and Schaufelberger, W., Design Of A Framework for Hardware-In-The-Loop Simulations and Its Application to a Model Helicopter, Automatic Control Laboratory, ETH, Zurich, 2001.

. Pascual, C., et.al., High-Fidelity PWM Inverter for Audio Amplification Based On Real-Time DSP, Disertation, Department of Electrical and Computer Engineering, University of Illinois, Urbana, Illinois, 2002.

. Purcell, A., and Paul, P.A., Enhanched Inverter Switching for Fast Response Direct Torque Control, IEEE Transc. On Power Electronics, Vol.16, No.3, 2001.

. Sutrisno, B., Pengendali Kecepatan Putar Motor Induksi Tiga Fasa Dengan PWM Berbasis Mikrokontroler 68 HC11, Tesis S2, Universitas Gadjah Mada, Yogyakarta, 1999.




DOI: http://doi.org/10.12928/telkomnika.v6i2.554

Refbacks

  • There are currently no refbacks.


Creative Commons License
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.

TELKOMNIKA Telecommunication, Computing, Electronics and Control
ISSN: 1693-6930, e-ISSN: 2302-9293
Universitas Ahmad Dahlan, 4th Campus
Jl. Ringroad Selatan, Kragilan, Tamanan, Banguntapan, Bantul, Yogyakarta, Indonesia 55191
Phone: +62 (274) 563515, 511830, 379418, 371120
Fax: +62 274 564604

View TELKOMNIKA Stats